配资盘歡迎您的到来!

歡迎光臨慧投金融配资官網!【配资盘】材料生産,銷售和施工的高新技術企业.

    示例圖片三
    網站首頁 > 新聞资訊 > 配资盘

    環氧自流平地坪漆施工前必須知道的幾個要點

    2019-06-14 14:11:46 慧投金融配资 閱讀

    環氧自流平地坪漆主要是針對一般配资盘塗料難以达到GMP規範中對高潔淨場所的嚴苛要求,以100%固含量的特種環氧樹脂为基料配制而成,具有綠色環保,光澤度高,一次性成膜厚,漆膜強韌耐磨等優良特性,是潔淨度要求高的電子企业廠房、制藥企业廠房等場所理想的塗裝系統。環氧自流平地坪漆是比較高檔的一款地坪漆産品,其主要特點就是高度潔淨、美觀,環保、施工效率高。但是如果在施工過程中如果操作不當,就會出現質量問題,甚至需要返工,浪费人力物力。那麼環氧自流平地坪漆施工時需要注意到哪些細節呢?下面配资盘漆廠家就給大家詳細說明。

    Epoxy self-leveling floor paint is mainly made of special epoxy resin with 100% solid content as binder, which is green, environmentally friendly, glossy, one-time film-forming thickness, toughness and abrasion resistance of paint film. It is an electric paint with high cleanliness requirement. Ideal floor painting system for sub-enterprises and pharmaceutical enterprises. Epoxy self-leveling floor paint is a relatively high-grade floor paint product, its main characteristics are high cleanliness, beautiful, environmental protection, high construction efficiency. But if the construction process is not properly operated, there will be quality problems, even rework, waste of manpower and material resources. Then what details should be noticed in the construction of epoxy self-leveling floor paint? The following epoxy floor paint manufacturers will give you a detailed description.1、首先确定地面是否适合直接做環氧自流平地坪漆,如果基層落差過大那麼需要先打磨處理,2平方米内落差>3毫米地面不平、 2平方米内落差<=3毫米 地面合格 、2-3平米内落差>=5-10毫米嚴重不平。

    1. Firstly, determine whether the ground is suitable for making epoxy self-leveling floor paint directly. If the base level drop is too large, it needs to be polished first. The drop within 2 square meters is more than 3 mm, the drop within 2 square meters is less than 3 mm, the drop within 2-3 square meters is less than 3 mm, and the drop within 2-3 square meters is more than 5-10 mm.2、環氧自流平地坪漆施工現場门窗封閉嚴密,施工現場應为封閉空間。施工區域不得交叉施工。否則會因为灰塵、昆蟲等雜物落在表面塗層導致環氧自流平地坪漆表面粗糙不平整。

    2. The doors and windows of the construction site of epoxy self-leveling floor paint are tightly sealed, and the construction site should be a closed space. No cross-over construction is allowed in the construction area. Otherwise, because of dust, insects and other debris falling on the surface coating, the surface of epoxy self-leveling floor paint is rough and uneven.3、環氧自流平地坪漆施工溫度≥5℃,若要在<5℃施工的,選用特殊配方。濕度建議在75%以下施工。施工時确保空氣流通。調制使用量時,不能超過30分鐘。防止環氧自流平地坪漆出現不幹、表面發白的問題。

    3. The construction temperature of epoxy self-leveling floor paint is above 5 C. If the construction temperature is below 5 C, special formulation should be selected. Humidity is recommended below 75%. Ensure air circulation during construction. The modulation dosage should not exceed 30 minutes. Prevent the problem of non-drying and surface whitening of epoxy self-leveling floor paint.4、为了避免環氧自流平地坪漆發花、表面起粉等問題的發生,水泥基自流平砂漿施工時應嚴格控制加水量,施工時應先确定标準的加水量,并設专人稱量加水,保證材料在整個施工過程中加水量一致,同時也要保證每桶材料攪拌時間大致相當,保證攪拌充分和均勻。

    4. In order to avoid the problems of paint blooming and surface powder on epoxy self-leveling floor, the amount of water added should be strictly controlled during the construction of cement-based self-leveling mortar. The standard amount of water added should be determined first, and a special person should be set to add water to ensure that the amount of water added in the whole construction process is the same, and the stirring of each barrel of material should also be ensured. The mixing time is approximately the same to ensure that the mixing is adequate and even. 


    标簽:   地坪 配资盘 配资盘漆 配资盘施工 無錫配资盘
    無錫配资盘 技術支持: